ADVrider

Go Back   ADVrider > Search Forums
User Name
Password
Register Inmates Photos Site Rules Search Today's Posts Mark Forums Read

Showing results 1 to 40 of 500
Search took 0.05 seconds.
Search: Posts Made By: El Ponkin
Forum: OZ Vendors 03-24-2015, 03:03 AM
Replies: 140
Views: 715,154
Posted By El Ponkin
KTM 690 Engine 2011 34000kms

Selling my original KTM 690 Engine 2011 34000kms,I have owned this since new. The main input shaft broke and as it separated at an angle it pushed the clutch bearing out of the main engine casing. I...
Forum: Thumpers 03-23-2015, 03:15 AM
Replies: 121
Views: 14,601
Posted By El Ponkin
Mr KTM sent me some pressies, now the build...

Mr KTM sent me some pressies, now the build begins, I have the new shaft assembled just getting the serial number engraved on the new casings and then I can get it all preassembled for freeplay...
Forum: Thumpers 03-22-2015, 12:52 PM
Replies: 21,724
Views: 2,615,751
Posted By El Ponkin
Thanks Steve appreciate the help. Andy

Thanks Steve appreciate the help.
Andy
Forum: Thumpers 03-21-2015, 02:48 PM
Replies: 21,724
Views: 2,615,751
Posted By El Ponkin
I have to change the throttle cable on my 2011...

I have to change the throttle cable on my 2011 690R, frankly messing with the throttle body fills me with dread as I haven't had any issues and don't want any.

Looking at the pic below it looks...
Forum: Australia 03-20-2015, 11:41 AM
Replies: 2
Views: 340
Posted By El Ponkin
The Reid Brothers Ride the World

Met these guys on the APC Rally in 2012, helped them out a couple of times, good to see them going on to bigger rides and in this case for a very worthwhile cause obviously very close to their...
Forum: Australia 03-17-2015, 12:50 PM
Replies: 84
Views: 7,244
Posted By El Ponkin
There is a diversion route for the big bikes and...

There is a diversion route for the big bikes and I think there are quite a few doing that on the 1190s, not sure about any beemers.
Andy
Forum: Australia 03-15-2015, 06:16 PM
Replies: 5,462
Views: 605,932
Posted By El Ponkin
Yes I bought Big Willys spare engine and fitted...

Yes I bought Big Willys spare engine and fitted that straight away, was only off the road for a week :wink:
KTM have supplied all the parts to rebuild my original engine and they have just arrived...
Forum: Australia 03-15-2015, 12:39 AM
Replies: 5,462
Views: 605,932
Posted By El Ponkin
As you were on the beach I would go for the spark...

As you were on the beach I would go for the spark plug cap and also replace the spark plug. Thermal shock from the water can crack the central electrode and the plug cap is fairly basic and can get...
Forum: Australia 03-14-2015, 11:44 AM
Replies: 5,462
Views: 605,932
Posted By El Ponkin
Need to know what you have done to it since it...

Need to know what you have done to it since it was last running right to have any clue to what you have going on ?
Check my sig line for my troubleshooting guide.
At a wild guess and with...
Forum: Australia 03-13-2015, 04:17 PM
Replies: 84
Views: 7,244
Posted By El Ponkin
Completed my final pre-ride last weekend with...

Completed my final pre-ride last weekend with full Coast to Coast set up including full fuel and water, very happy with the set up and handling after a 1000km two dayer which had some gnarly bits...
Forum: Australia 03-13-2015, 12:56 PM
Replies: 84
Views: 7,244
Posted By El Ponkin
I think there will most likely be a 50/50 ratio...

I think there will most likely be a 50/50 ratio of experienced and less experienced riders, the experienced ones I am sure will be helping the less experienced get through. Most of those involved I...
Forum: Thumpers 03-12-2015, 01:07 AM
Replies: 121
Views: 14,601
Posted By El Ponkin
Thanks for the feedback guys, will follow up on...

Thanks for the feedback guys, will follow up on your suggestions.
Andy
Forum: Thumpers 03-10-2015, 03:25 AM
Replies: 21,724
Views: 2,615,751
Posted By El Ponkin
I think it was a dongle fault but he certainly...

I think it was a dongle fault but he certainly had reduced power and when he removed the dongle it was back to full power. He didn't get to the bottom of it as he was just happy to remove it and get...
Forum: Thumpers 03-09-2015, 11:46 PM
Replies: 21,724
Views: 2,615,751
Posted By El Ponkin
It does both bad fuel and ABS on the 1190 and is...

It does both bad fuel and ABS on the 1190 and is selectable via the dash, it is selectable via switch combinations on the 690 for ABS but still has the bad fuel capability and it did this on a mates...
Forum: Thumpers 03-09-2015, 11:27 AM
Replies: 121
Views: 14,601
Posted By El Ponkin
Watching with interest, I am still waiting...

Watching with interest, I am still waiting delivery of my new half cases.
Have you figured out how you are going to measure the end float on the shafts as the book says to preassemble and then...
Forum: Thumpers 03-09-2015, 11:20 AM
Replies: 21,724
Views: 2,615,751
Posted By El Ponkin
The ABS Dongle is the same used on the bigger...

The ABS Dongle is the same used on the bigger KTMs and has the ability to switch on the bad fuel setting normally done by the switch under the seat. When the dongle is used on the 1190 the bad fuel...
Forum: Thumpers 03-09-2015, 10:59 AM
Replies: 51
Views: 22,405
Posted By El Ponkin
PM sent ref Wiring Manual. My only other...

PM sent ref Wiring Manual.
My only other suggestion is KTM Dealers have access to a wiring "Break out" box which they can use to check out the loom for defects, there are a few units distributed...
Forum: Thumpers 03-09-2015, 04:38 AM
Replies: 51
Views: 22,405
Posted By El Ponkin
My best guess is that one of the ECUs may have...

My best guess is that one of the ECUs may have been damaged but that is a big guess, can you loan a 2012 pair of ECUs to try.

Andy
Forum: Thumpers 02-27-2015, 08:19 PM
Replies: 1,304
Views: 181,966
Posted By El Ponkin
Less engine braking is because of the high idle, ...

Less engine braking is because of the high idle,
Your idle figure is abnormally high as EVO 1 idle is same as standard.
Try the throttle calibration again and if still the same reflash the maps....
Forum: Thumpers 02-25-2015, 11:18 AM
Replies: 1,304
Views: 181,966
Posted By El Ponkin
Frankly I wouldn't have thought the bike would...

Frankly I wouldn't have thought the bike would run at all with only 0.3 volts in the Throttle circuit. If you reload the other map and everything runs normally you may find the voltage indication in...
Forum: Thumpers 02-24-2015, 11:42 AM
Replies: 1,304
Views: 181,966
Posted By El Ponkin
From TuneECU User Guide: Sensors The...

From TuneECU User Guide:

Sensors
The values, state, or voltage (V) of all other sensors are listed on the left side of the display. Move your mouse over the value and a highlighted text will give...
Forum: Thumpers 02-23-2015, 02:32 AM
Replies: 12
Views: 421
Posted By El Ponkin
Look down by your gear lever, just in front is...

Look down by your gear lever, just in front is your gear position sensor, follow the wires up to the connector up on the frame just above the engine, disconnect the plug and locate the green and...
Forum: Australia 02-21-2015, 02:17 PM
Replies: 84
Views: 7,244
Posted By El Ponkin
I'm in, 690 Rally Raid EVO 1. What fuel load are...

I'm in, 690 Rally Raid EVO 1. What fuel load are you carrying ? I was working on 32 litres all up, bike + bladder.

Andy
Forum: Thumpers 02-14-2015, 09:09 PM
Replies: 17
Views: 2,194
Posted By El Ponkin
Glad it worked out, enjoy. Andy

Glad it worked out, enjoy.
Andy
Forum: Thumpers 02-09-2015, 01:12 AM
Replies: 17
Views: 2,194
Posted By El Ponkin
All the info you need is in the EFI Idiots Guide...

All the info you need is in the EFI Idiots Guide and If you have dramas with your 690 the troubleshooting guide. Links to both in my signature block. I know they look daunting but it is way better...
Forum: Thumpers 02-02-2015, 11:42 AM
Replies: 28
Views: 3,353
Posted By El Ponkin
Have followed your mod closely with interest...

Have followed your mod closely with interest great work mate.
Andy
Forum: Australia 02-02-2015, 11:34 AM
Replies: 3
Views: 523
Posted By El Ponkin
Adventure Bike TV

Check this out, it is done by Pommies but seeing as there is nothing else out there on TV for us it isn't that bad and has some interesting bits, love the rip off of the Stig, their version is "Bob"....
Forum: Thumpers 02-02-2015, 01:31 AM
Replies: 28
Views: 3,353
Posted By El Ponkin
Thanks for the positive vibes suggest you Just...

Thanks for the positive vibes suggest you Just copy it to your smart phone as a doc or pdf !

Andy
Forum: Australia 02-02-2015, 01:25 AM
Replies: 5,462
Views: 605,932
Posted By El Ponkin
Just turn the throttle upside down, I have...

Just turn the throttle upside down, I have Pastrana bars and 2.5 in risers and still have plenty of room to play.

Andy
Forum: Thumpers 02-01-2015, 11:45 AM
Replies: 13
Views: 1,039
Posted By El Ponkin
I reckon another case of thermal shock cracking...

I reckon another case of thermal shock cracking the central electrode, interesting, maybe a draw back of these new high tech plugs.

Andy
Forum: Australia 01-31-2015, 05:17 PM
Replies: 226
Views: 34,630
Posted By El Ponkin
Its a fairly standard forming process with...

Its a fairly standard forming process with aluminum using a rounded mallet and laying the ally in a sandbag.
You can form a dish real easy, the ally then age hardens to become strong.
Forum: Australia 01-31-2015, 12:06 PM
Replies: 226
Views: 34,630
Posted By El Ponkin
I don't think it counts as an upgrade when you...

I don't think it counts as an upgrade when you kill your old one :lol3
Andy
Forum: Australia 01-31-2015, 12:04 PM
Replies: 66
Views: 3,326
Posted By El Ponkin
Reckon you need to amp up the commentary, more...

Reckon you need to amp up the commentary, more like "Steve Irwin" , You would do well doing the narration for some 70's porn classic, just sayin, :lol3

Andy
Forum: Australia 01-29-2015, 10:48 PM
Replies: 226
Views: 34,630
Posted By El Ponkin
Baggies first refusal when you flog it :evil ...

Baggies first refusal when you flog it :evil
No hang on not sure I will be ready for an upgrade in that time span. :rofl:rofl:rofl

Andy
Forum: Thumpers 01-29-2015, 11:53 AM
Replies: 10
Views: 1,812
Posted By El Ponkin
Tank vents don't really need filtering just loop...

Tank vents don't really need filtering just loop them up high and point end downwards.
Canisterectomy doesn't need a resistor if you install euro mapping with tune ECU .
Removal of SAS doesn't...
Forum: Thumpers 01-27-2015, 12:42 AM
Replies: 13
Views: 1,039
Posted By El Ponkin
Try not to take offence mate but these guys have...

Try not to take offence mate but these guys have got a lot of experience on these bikes and this forum. Experience has shown that with the KTM EFI systems the water sealing isn't that good and...
Forum: Australia 01-26-2015, 11:36 PM
Replies: 52
Views: 4,140
Posted By El Ponkin
It is interesting to see that in the Dakar they...

It is interesting to see that in the Dakar they are becoming lower in profile, maybe the next generation will be less restrictive.


Another option is the airbag jacket that Scott recently...
Forum: Australia 01-26-2015, 12:02 PM
Replies: 52
Views: 4,140
Posted By El Ponkin
I have worn one ever since my son's accident, I...

I have worn one ever since my son's accident, I just treat it like a helmet and consider it is mandatory for me to wear if I want to ride. All of it's annoyances I have got over and now don't give it...
Forum: Thumpers 01-25-2015, 10:51 PM
Replies: 13
Views: 1,039
Posted By El Ponkin
Try dousing it in WD40 first. If not then it...

Try dousing it in WD40 first.
If not then it is normally the spark plug cap or wire to it, you can unscrew the cap from the wire and cut off about 1/4 in (5mm) of wire and then rescrew on the plug...
Forum: Thumpers 01-25-2015, 01:39 PM
Replies: 910
Views: 254,321
Posted By El Ponkin
What about my build thread has that got the pics...

What about my build thread has that got the pics you want ?

http://www.advridermag.com.au/forum/showthread.php?31-KTM690-Rally-Raid-Build

Andy
Showing results 1 to 40 of 500

 
Forum Jump

Times are GMT -7.   It's 11:08 AM.


Powered by vBulletin® Version 3.8.5
Copyright ©2000 - 2015, Jelsoft Enterprises Ltd.
Copyright ADVrider 2011-2015